Does your AC blow COLD?

Hi, I have a question about the 996 A/C. It was in the mid 80's the last couple of days in Boston and I was in my '99 996. I bought the car in October and have never really used the A/C, but when I used it the other day, it seemed to be blowing almost hot air. In my X5, the A/C blows ice cold and right from when you turn on the car. It never even got kind of cold in the 996. My guess is I need some more coolant or there is a leak, but I just wanted to check in with the experts. If I do need an A/C service, any places to suggest in the Boston area? Thanks.

I would say yes my A/C works wonderfully.

Measure the outlet temperature. It should be <55F.

Yah-- mine is pretty solid. As good or better than the ac in my (now ex) ML.

brrr... very cold. Good enough for Florida summer with a black car. It took a full custom hose job, 3 desert grade condensers and new compressor to get my 87 3.2 cold. A major factor for me in upgrading to a 996.

My gets extremely cold, usually only have the fan on 1-3 bars on the hottest days in TX

my AC is good enough for me to put the top down when temp is 105 degree. if i remember correctly, you are the first one comes to 996 board with AC problem. 996 's AC is as reliable as toyota, shall we say?

Should be, they use Denso compressors

A refreshing change compared to the nightmares I had with my 944's A/C. Cost me a fortune to finally buy a new compressor and upgrade to newer refrigerant. Booooo!

+1

May be time to do a recharge of the AC gas? I know that Kragen type stores sell kits. Anyone know if the 996 uses R-12 Equivalent, R-22 or R-134a? Could also be leaking system or failing compressor of course, as you said.

A not proper working AC is actually a not too seldom issue in early 996. This is what my 996 buyers-guide says: "Air con faults. Earlier 996 can have leaks, most times from the condenser. If so you might find the car will not cool sufficiently or cool at all. A re-gas in this case will be a waste of time. After a few years air con systems can gradually loose their efficiency and require a re-gas, typically you get cool air, but not as cold as possible." I actually had a leak in my 996 and had a broken AC O-ring in my BMW X3. Both got fixed pretty easy.

mine gets pretty cold.... if you don't use it, you WILL loose it........

Almost all modern day automatic climate control systems, including yours, use an internal airflow reheat/remix method so the airflow exiting the system is not so COLD as to be discomforting. There are two ways you might feel really COLD airflow from the system. One, if the cabin temperature is so high that it takes lots of cooling to quickly bring it down to your setpoint. And two, if you improve the system's overall efficiency dramatically by moving the setpoint to maximum cooling and then use LOW blower speeds. This latter method effectively bypasses the reheat/remix function. In any case there is a design flaw in the Porsche 996 (& Boxster, cayenne, etc.) climate control system which I believe was carried over to the 997 series. Once the cabin temperature is very near or at your temperature setpoint the system will begin routing HUGE volumes of CHILLING airflow to the interior surface of the windshield via the defrost/defog/demist airflow ducts. This is not only extremely wasteful of the system's cooling capacity it can lead to a VERY dangerous, HAZARDOUS situation. Sudden windshield fogging.... On the exterior of the windshield. My wife and I took factory delivery of our 2001 C4 and when we turned it back in I told the factory rep that something was amiss with the climate control as I had to keep "dithering"(***) with the setpoint in order to maintain our comfort level. We picked it up on the east coast and were approaching Birmingham AL in the early evening on a HOT late June day and after just having driven through a rainstorm. I didn't immediately notice why it was getting harder and harder to see forward until I finally came to the realization that the windshield was fogging over on the outside. We happened to also have a '99 996 at the time so when I got home I verified that it would do the same thing. So if you want your Porsche climate control system to maintain your temperature setpoint more accurately and consistently ALWAYS manage the system air outflow manually. NEVER allow cooling airflow through the defrost/defog/demist ductwork. VW had this very same problem with their version of the Cayenne but quickly addressed it via a firmware change. Porsche not only denies it to be a problem they claimed, in writing, there is no comparison between the VW system and that in the Cayenne. *** What I later determined was that once the system switched over to routing cooling airflow to the windshield much of the cooling capacity of the system was lost into the great beyond and I had to lower the system setpoint to compensate. This can be avoided, obviously, by simply preventing the airflow from flowing out the defrost/demist/defog ducts.

OMG....another major flaw to add to the RMS, intermix, intermediate shaft.....and who only knows what's next. I'm going to go buy a Toyota....I've had it.

Funny, we have the exact same vehicles.. Anyway, I used mine today with the top down and a dash board reading of 90 degrees. It worked fine.

Yep, always cools the car right away, despite black interior in south Florida. One of the best advances over the old air-cooled cars is that we now have "real" A/C.

We all know this is a joke, we rather push our Porsches than drive Toyotas.

Tippy: Yes, it was meant to be a joke ...I guess I forgot the smiley

My wife was going for an overnight vacation and meet up with our daughter earlier today in another town. She didn't want to take her Boxster because she's afraid to leave it parked outside overnight at the hotel and such. But her '06 Lexus 400h Hybrid with 11k miles broke down and will have to be flatbedded to the dealer. So much for Toyota reliability. She will have a new appreciation for her Boxster, I'm sure.

I checked my vent temps with an OAT of about 90 degrees and got 51 degrees from the center vent. Colder than my wifes Toyota

Toyotas come with A/C? Is that standard or optional?

Yup, always works. Now if I just could get over the weird way the controls work. A lot of button pushing ...

I use the manual setting too. It is 90+F here and I noticed the air temperature set at 69 deg was not as effecient as it was a couple weeks ago. My solution -turn temp down to 64 deg. There has to be a way to re-charge the system. Now lets find out how.

Yes, only when I'm not WOT, which isn't very often. And no it's not cold as soon as I start my car but once I get moving it cools down quite well.

Our 1999 a/c blows nice and cold but It did require a repair a few year ago. I'm not sure what the part number is, but it is a line that runs under the car from the engine (presumably compressor) to the front condensor. Not too cheap, and it was back-ordered over a month so I'm assuming it may be a common fault. The a/c works far better than our ML, but I'm not sure as well as our old 928 did. On a side note, we still have a 2000 Cavalier Z24 (no jokes please - it was my car at university and now my fathers daily run about - and possibly the most reliable car we've had..) and it has by far a better a/c system than any German car, new or otherwise we've ever owned. If there is one thing the American's can do it's a/c!

Yes.....I LOVE my a/c...due to the fact that my air cooled targa's a/c was basically non existent. It was ninety here today.....no issues with the a/c....never really had it over half blast too long. I did notice some outside fogging btw....just a bit...nothing that obscured my view. I do notice however that in the center vents....the left vent blows a bit less than the right...anyone else have that? and yes...both vents are fully open with the side adjustment. J

Mine gets high marks on the "Nipple Meter" and I turn it on briefly whenever I drive the car in the Fall and Winter.

Uh oh....

I have seen some triple digit temps in bright sun here the past week. It has mostly been ~95, but it most certainly has been triple digit at times. AC is enough to freeze you out, even with the fabric top. 100% it works better than my ML.

This morning it was 94 on the way to work and I was cold in my car.... Had to turn the air up!

I haven't found anything different in your 996 that would prevent a qualified ac tech from evacuating and charging your system. If any leaks are present then you can go from there. The dryers are good but may require replacement. The evaporator should be good.